Looking for:
2007 kawasaki mule 3010 service manual pdf download |
2007 kawasaki mule 3010 service manual pdf download
Quick Links. Table of Contents. Property of www. Previous Page. Next Page. Kawasaki mule trans 4x4 utility vehicle owner's manual pages. Page 2 Property of www. Page 4 Property of www. Page 5 Illustrations and photographs in this publication are intended for reference use only and may not depict actual model component parts. They are designed to give optimum performance while maintaining a low noise level. Please do not remove these systems, or alter them in any way which results in an increase in noise level.
Page 10 Property of www. Model Identification General Specifications Unit Conversion Table To facilitate actual operations, notes, illustra- tions, photographs, cautions, and detailed descriptions have been included in each chapter wherever necessary. 2007 kawasaki mule 3010 service manual pdf download, O-rings, Oil seals, Grease seals, circlips or cotter pins must be replaced with new ones whenever disassembled.
Then tighten them according to the specified se- нажмите сюда to 2007 kawasaki mule 3010 service manual pdf download case warpage or deformation which can lead to malfunction.
Be sure to maintain proper alignment and use smooth movements when installing. Ball Bearing and Needle Bearing Do not remove pressed ball or needle unless removal is absolutely necessary.
Lubri- cation points are called out throughout this manual, apply the specific oil or grease as specified. Direction of Engine Rotation When rotating the crankshaft by hand, the free play amount of rotating читать больше will affect the adjustment. Overall Width 1 mm Overall Height 1 mm Wheelbase 2 mm Track: Front 1 mm Rear 1 mm Ground Clearance Page 22 Property of www. Spark Arrester Cleaning Engine Lubrication The initial maintenance is vitally important and must not be neglected.
MO: Apply molybdenum disulfide oil solution mixture of the engine oil and molybdenum disulfide grease in a weight ratio Brake Pedal Play — — — If the throttle pedal does not return properly, lubricate the throttle cable. If the free play is incorrect, adjust the throttle cable. If the filter is clear with no signs of dirt or other contami- nation, it is OK and need not be replaced.
If the filter is dark or looks dirty, replace it. Also, check 2007 kawasaki mule 3010 service manual pdf download rest of the fuel system for contamination.
Keep the steam gun [A] away more than 0. Hold the steam gun perpendicular to the core sur- face. If necessary, replace the belt with a new one. Check both rocker arms are free.
If not, turn the rotor more one turn and free both rocker arms. Since the engine must be run dur- ing this procedure, the muffler will become hot. Then stop the vehicle. If the tire is cut or cracked, replace it. If the fluid level is lower than the lower level line, check for нажмите сюда leaks in the brake lines, and fill the reservoir to the upper level line.
If the fluid in the reservoir runs completely out any time during fluid changing, air bleeding must be done since air will have entered the line. Bend and twist the rubber hose while examining Replace it if any 2007 kawasaki mule 3010 service manual pdf download or bulges are noticed.
If any measurement is greater than the service limit, re- place the drum. Count the number of notches clicks during lever travel. If lever travel is not correct, adjust it. Gently turn [B] the steering wheel left and right. The steering wheel free play is the amount 2007 kawasaki mule 3010 service manual pdf download travel in the steering wheel, before the front wheels begin to turn.
The brake light should go on after 10 mm 0. If it does not, adjust the brake light switch [A] up or down. Also, check to see that each cotter pin is in place and in good condition.
Choke Cable Lubrication Choke Cable Inspection Idle Speed Adjustment SS: Apply silicone sealant Kawasaki Bond: around the tubes. Throttle pedal free play — — — Governer Link Mechanism 0. Governor Arm 2. Pivot Arm 3. Link 4. Hole 5. Turn the pivot arm. Turn the governor arm. Carburetor Throttle Full Open 8. Throttle Full Open 9. Governor Arm Clamp Nut Standard: If the clearance is not within the specified range, adjust the clearance by adding or removing the shims.
Pull the choke knob until the starter lever [B] on the carburetor begins to turn; If the cable does not move freely after lubricating, if the cable is frayed, or if the housing is kinked, replace the cable. Because of the danger of highly flammable liquids, do not use gasoline or low flash -point solvents to clean the carburetor. If the gasket is not in good condition, replace it. If there are any cracks, replace the float. Turn the ignition switch OFF.
Do not smoke. Make sure the area is well-ventilated and free from any source of flame /8346.txt sparks; 2007 kawasaki mule 3010 service manual pdf download the main switch OFF.
Make sure the area is well-ventilated and free from any source подробнее на этой странице flame or sparks; this includes any appliance with a pilot light. Fuel По этому адресу Installation If the rubber dampers [A] were removed, install them onto the fuel tank with an adhesive. Flow Chart Coolant Level Inspection Coolant Draining Coolant Filling Pressure Testing Water Pump Radiator 2. Radiator Fan 3. Radiator Cap 4. Reservoir Tank по ссылке. Water Pump 6.
Cylinder 7. Thermostat 8. 2007 kawasaki mule 3010 service manual pdf download Temperature Warning Light Switch 9. Air Bleeder Bolt Water Pipe
MULE™ 4x4 Service Manual KAFE/F/G/H | Kawasaki Motors Corp., U.S.A..Kawasaki Mule Service & Repair Manuals
Honeywell manual Links. Table of Contents. Previous Page. Next Page. Kawasaki mule trans 4x4 utility vehicle owner's manual pages. Utility Vehicle Kawasaki mule Service Manual pages. Page 5 All rights reserved. They are designed to give mmule performance while 2007 kawasaki mule 3010 service manual pdf download a low noise level. Please do not remove these systems, or alter them in any way It also precedes the text of a NOTE.
Model Identification General Specifications Periodic Maintenance Chart To facilitate actual operations, notes, illustra- tions, photographs, cautions, and detailed descriptions have been included in each chapter wherever necessary.
If there is any doubt as to the condition of them, replace them with new ones. Abrasion Crack Hardening Warp Bent Overall Width 1 mm Overall Height 1 mm Wheelbase 1 serfice Track: Front The initial maintenance is vitally important and must not be neglected.
O: Apply an oil kzwasaki the threads, seated surface, or washer. Muld Lead 2. Main Harness 3. Band Do not tighten band on wire connector joint. Power Outlet Connector 4. Ignition Switch 5. Hour Meter 6. Ссылка Cable По ссылке 7. Horn Switch Lead 8. Downlaod Fan Motor 2. Radiator Fan Motor Lead 3. Radiator Fan Switch 4.
Horn Lead 5. Radiator Fan Motor Tube 7. Brake Light Switch 8. Brake Master Cylinder 2. Keep hose away mxnual steering intermediate shaft. Install clamp in this direction. Main Harness Radiator Fan Switch Lead 2. Choke Cable Horn Lead 3. Differential Shift Cable Brake Light Switch Brake Pipe 5. Ignition Switch Lead 6. Headlight Lead Left 7. Headlight Lead Right 8. Main Harness 9. Breather Tube kawasaku. Brake 2007 kawasaki mule 3010 service manual pdf download 3. Ссылка на продолжение Pipe 4.
Clamp 5. Front Brake Master Cylinder 2. Harness 4. Band 6. 2007 kawasaki mule 3010 service manual pdf download Brake Drum 7.
Left Bracket 2. Right Bracket 8. Screw 3. Myle Tube 9. Clamp 4. Brake Pipe Band 5. Brake Cable Fuel Hose 6. Left Brake Drum Differential Shift Cable 8. Parking Brake Cable 2.
Throttle Cable 9. Left Parking Brake Cable 3. Transmission Shift Cable Right Parking Brake Cable 4. Leaf Spring 5. Power Outlet Connector Lead 2. Position Mark White Tape Water Temperature Warning Indicator 3. Brake Pipe Joint Light Lead 4. Accessory Connectors Ignition Switch Lead 5. Headlight Lead Left Steering Main Shaft Band 2. Fuel Kawasaji Band European Model only 3. Cover Neutral Switch Lead Fuse Box нажмите для деталей. Parking Brake Switch Lead 3.
Starter Circuit Relay 4. Ground Lead Frame 5. Starter Motor Cable 6. Ground Lead Engine 7. Plug 8. Band 9. Reverse Light Switch Lead European Model Carburetor 3.
No comments:
Post a Comment